The British 8th Army sends their desert expert -- Jack Moffitt -- to the Rat Patrol for one very special mission. But Sergeant Troy (the American head of the unit) is very uneasy about this new addition. Moffitt tells Troy that the Germans have buried ammunition and petrol at an abandoned oasis which only the Afrika Korps knows about. It's up to the Rat Patrol to find this oasis and destroy the cache before the Germans can reach it. Dietrich -- familiar with the Rat Patrol's tricks -- devises a trap wherein he will follow the Patrol to the oasis. The Rat Patrol gets delayed, though, by a broken axle and, in the end, it is a race between them and Dietrich to see who will reach the supplies first.

During a desert battle, Hitchcock is badly wounded. Troy decides to risk taking him to a nearby German field hospital as their own hospital is too far away. Upon arriving at the hospital he and Moffitt nearly pull off the masquerade, except for a paranoid patient -- Captain Friedrich -- who tells everyone they are American spies. No one believes him but during the delay the doctor notices a tattoo on Hitch's arm from Ft. Benning, Ga. Troy forces him, at gunpoint, to finish the operation. They escape in a hail of gunfire after the surgery.

As a prequel to capturing General Ernest von Helmreich, the Rat Patrol gets itself captured. They plan to use the general to stop an upcoming attack. However the general manages to attract the attention of a distant Nazi search party and the Rat Patrol ends up trapped in a ravine, cut off. To escape they construct a ""fake panzer unit"" of their own -- tricking the Germans into a retreat. They then make it to the largest of the Germans' ammo dumps which they proceed to blow up.

Dietrich is presented with an old scrap of parchment which shows an ancient water source deep in the desert. Allied intelligence sends Moffitt to find the map before it can be translated; he must get it by masquerading as a German and Troy has orders to shoot him should he find the information (and destroy it) but then not be able to escape. Which is, of course, exactly what then happens. Troy must face the decision of killing his comrade -- and friend -- or finding someway to disobey the orders and rescue the mission.

The Patrol captures a German truck at the end of a partially destroyed convoy. In the process, though, Troy and Dietrich end up alone in the desert -- a stand-off until Arab slave traders arrive and capture both, hauling them deeper into the southern desert on the first leg of the slave trail. Troy and Dietrich escape but are chained together and must make their way back to ""civilization"" through the heat, the sand, and the enemy -- both enemies. They agree, after both are nearly dead with exposure, to cooperate. The truce ends when they arrive at Dietrich's column, but before they get down to the convoy, Troy trips and Dietrich ends up unconscious. Troy frees himself and Dietrich is picked up by his people. Troy rejoins Hitch, who has been driving along at the end of the column. They reach an oasis and Troy is able to place the explosives which were the purpose of this farce in the first place. The oasis blows up and the Rat Patrol, again, escapes.

A large Panzer unit has a map showing a strategic oasis occupied by the Eighth Armored. U.S. Intelligence wants the map exchanged for a phony one which would show the oasis as empty. Accompanied by a veteran map expert, Sgt. Griffin, Troy and his men start into the German HQ. At midnight, using bows and arrows for weapons, they go into the area but Griffin has a heart attack and the team is trapped in the commander's office. In the end, Troy bullies the ""expert"" into keeping up the effort until they are finally able to finish the mission, whereupon Troy ends up endangering his own life to get Griffin out of the town.

During a skirmish with the Germans, Troy suffers a concussion from an explosion. He ends up alone and lost in the desert. By the time he is found he has a terrible case of sunblindness. Unknown to Troy, though, his ""rescue"" has been by a German unit that is pretending to be Americans so they can coax Troy to tell him where the rest of the Rat Patrol is. Dietrich is the engineer behind this ploy.In the end, recovering from the sunblindness in the nick of time, Troy escapes.

The Patrol manages to ambush a German unit that is carrying US POWs. Three of these POWs are apparently out to kill each other. Sgt. Gribs -- whose cowardliness caused his men to become captured -- is fighting against Tex and Eddie -- who want revenge. Gribs bargains with Troy for protection, telling Troy that he has information vital to US Command. They start back to HQ, but one of the unit's jeeps breaks down. They continue to travel slowly across the desert until they can capture a German vehicle. Gribs parcels out small hints of his ""vital"" information to keep himself safe. It all ends in heroism -- or something close.

A very prized Germany radar station must be destroyed before a flight of bombers comes over. To do it, the Rat Patrol is given a new, special kind of explosives. Troy is apprehensive about carrying this dangerous cargo, which can explode with the slightest of bumps. Dietrich learns of the mission and tries to beat the Patrol to the area by utilizing an old Arabic legend of an unknown ""trigh"" (road) through the jebels (mountains). The Patrol is also in search of this trigh. But Moffitt gets them lost and Dietrich beats them there. Troy then manages to plant some explosives -- and bluffs Dietrich out of the radar station by telling him that he's willing to die himself rather than let the station do its work.

Fanatical Arabs -- wanting to end the war on their land -- attack both the Rat Patrol and the German convoy that Dietrich leads, trapping both in a small desert fortress. This forces the two teams into a truce. One of the Germans -- a liasion to the Arabs -- tries to talk Dietrich into betraying the Rat Patrol to the Arabs but he refuses. In the end the liasion tries to go over to the Arabs himself. He ends up killed, and Dietrich and Troy are able to construct a trap of their own -- killing most of the Arabs and escaping.

Moffitt and Tully allow themselves to be captured so that they can get information from Craig -- an American POW -- about Rommel's new battle plans. However, Marston, another POW, tells them that Craig died. Dr. Phillips -- the camp medic -- supposedly has some information about the plan, though. When the medic treats Moffitt's arm he puts the code name of the mission on the underside of the bandage : Operation Nachtigall. However, it soon becomes obvious that either Phillips or Marston is a traitor and it is up to the Patrol to figure out which, as they are both now giving the Patrol conflicting information.

An Arab convoy, disguised as Americans, traps and captures the Rat Patrol. The convoy's leader is Ned Cunningham, an ex-Yank hero turned gunrunner. He sells now to the highest bidder, no matter which side. He feels that the Rat Patrol is costing him too much business and so is going to eliminate them. But he then decides he likes the Patrol and will take them into the deal if they will cooperate. In the end, though, his duplicitious behavior causes his own death.

Tully and Moffitt transport a liberated French underground general to a rendezvous in a deserted lighthouse. Hitchcock stands lookout, disguised as a German guard. Troy, though, is held captive inside the lighthouse -- betrayed by Mathias. Moffitt tries to reach him but ends up unconscious. In the ensuing fight, Mathias is killed and Troy manages to signal the trawler into the area to take the general to safety.

German artillery traps 2000 Allied soldiers and their only chance of rescue is an Allied armored attack. The necessary equipment, though, can only reach them in time via an ancient road which is now hidden by sand, a road only Moffitt's father can find. On the way to the landing site, Moffitt's father's plane crashes. Moffitt wants to go find him but Troy insists their first priority is to find the road themselves. Moffitt breaks away and goes to find his father but finds only the burned-out plane. Troy thinks the elder Moffitt must be dead. Moffitt says he was captured. Again Moffitt escapes the team and goes after his father -- finally rescuing him.

After each Allied bombing of their harbor, the Germans use Allied POWs to rebuild it. HQ sends the Rat Patrol to liberate the POWs and halt the harbor's usefulness. Troy must coordinate his plans with Major Indrus (John Anderson), an American who is inside the camp. They use an explosive-laden boat to get into the harbor but the Germans stop it halfway in. The captain, Bertaine (Will Kuluva), doesn't allow the Germans to board his boat. Troy and his men are able to fight off the boarding party and escape into town, but at the cost of Bertaine's life. They are followed by El Gamil (Stanley Adams), a sympathetic Arab merchant and black marketeer, who provides a car and uniforms for Moffitt and Hitchcock to go to the German Officer's Club in search of Bertaine's daughter Marianne (Claudine Longet). She is regarded as a traitor by locals because she performs at the club, but Troy has no choice but to seek out her help. The episode ends with Moffitt and Hitchcock entering the club.

Moffitt and Hitch (dressed as Germans) find Bertaine's daughter and tell her of her father's death. Then they take her home - after they tell her who they really are. They also tell her that they need to use the fishing fleet to accomplish their mission. Meanwhile, Troy secretly meets with American POW liaison officer Indrus. Troy then joins Moffitt at the house of El Gamil. Informed of the plan, El Gamil dispatches his men to the various harbor areas to alert the fishermen. Troy sets the action to begin at dawn.

The plan is for the fishing fleet to bring out the prisoners, Dunkirk-fashion. However, a Nazi patrol boat has intercepted the boats. The fishermen believe that Marinanne is a collaborator. Sgt. Troy, though, disagrees and he's right. Marianne talks the fishermen into cooperating, and the prisoners make good their escape.

Gustav Luden (Jack Colvin), a radio operator, wants to defect, so he sends secret information to the Americans on a frequency that the Rat Patrol listens to. The Patrol goes in after him. They get inside the German base and, once there, find that Luden is being questioned by the Gestapo.

Valuable German ammo has been dropped by parachute to an Arab farmhouse, and the Rat Patrol is sent to destroy it. On destroying the building, Troy discovers that there is no ammo--but there is a confused teenage boy. The boy proves out to be the son of a German commander. Troy is going to kill the commander, but when the boy pleads with him not to, Troy remembers what it felt like to lose his own father, who died when Troy was this boy's age. Troy arranges to capture the German instead of killing him.

The Patrol's radio is wrecked and Troy is unable to warn HQ of a large Nazi anti-tank outfit waiting in ambush. Troy knows that El Jebel has a huge radio broadcast unit and heads there. Troy, Moffitt and the others make their way into the radio room and prepare to broadcast their warning to the British. However, Captain Deitrich walks in on them and takes them prisoner. Troy and Moffitt manage to escape. They free Hitch and Pettigrew and get their message back to London. This prevents the Allies from losing a lot of tanks.

Moffitt is seriously wounded in a raid on a German convoy. The Patrol is far from help and so Troy decides to obtain blood from a nearby German field camp. Dietrich is in charge of the base; Troy encounters him and orders him to help him find a donor. Dietrich sends for Corporal Pennell (guest appearance by teen idol Fabian Forte), a captured Yank deserter. Pennell refuses to cooperate but Troy takes him at gunpoint. On the way back to Moffitt, Dietrich catches up to them and it is up to Pennell to do the "impossible" to prevent them from all being recaptured. He rises to the occasion and they make it back to Moffitt and Tully in time to save Moffitt's life.

Troy and Hitchcock capture Col Beckmann, an infamous Nazi POW camp commander. Beckmann denies that he is the man. In a fight Troy is knocked out and Hitch is wounded. Using Troy's gun, Beckmann kills the other German taken at the same time he was and then he exchanges dog tags with him--the places the gun in Troy's hand. Troy is thus accused of the murder. Moffitt and Tully do not arrive until after the deed is done. To prove to a court-martial board that Beckmann is Beckmann, the other Patrolers must break into a German HQ--at considerable risk to their own lives.

Using a fake (German) Rat Patrol, Dietrich abducts an Arab holy man that he will then "rescue" so that the Arabs will give their help to the Germans. The real Patrol is captured by the Arabs, though, and when they convince the Arab leader--who is a friend of Moffitt's--that they aren't guilty, Troy and Moffitt go to find the holy man. To do so means a horse trip across the desert.

Using a telephoto lens, Moffitt and Troy photograph a map inside Captain Dietrich's office from the roof of the adjoining Nazi HQ. It shows the location of a top secret German ammo dump. The Patrol must reach the site, enter it and destroy it before half of the German army arrives. The Patrol arrive to find the storage area--an old mine--surprisingly deserted. They go about planting the explosives but just before they blow it, Dietrich (who has laid this all out as a trap) turns up. Shots are exchanged and Dietrich and Troy are trapped inside. Meantime, outside the mine, assuming that in the cave-in Troy was killed, Moffitt and the Patrol prepare to finish blowing it up. Working together, Troy and Dietrich escape through a back entrance moments before the dump is blown up.

The Brits and the Americans are planning a high-level meeting in a desert town. On the day prior to the event, the Patrol sights a German motorcyclist and chases him--but he gets away. Assuming that the Nazis must now know of the conference, Troy tries to talk the commanders out of the meeting. But, instead, they assign him to be in charge of the security. Troy gets jumped, while in town, by a knife-wielding Arab. Sgt Roberts, one of the other "security" men, rescues Troy. Unknown to them, though, Roberts is a double agent and is planning to blow up the meeting--a fact that Troy learns.